Carbon tetrachloride, Tetrachloromethane
Benziform, Benzinoform, Carbon chloride, Carbon tet, Freon-10, Refrigerant-10, Halon-104, Methane tetrachloride, Perchloromethane, Tetraform, Tetrasol
|Molar mass||153.81 g·mol−1|
|Density||1.5867 g cm−3 (liquid)
1.831 g cm−3 at −186 °C (solid)
|Melting point||−22.92 °C (−9.26 °F; 250.23 K)|
|Boiling point||76.72 °C (170.10 °F; 349.87 K)|
|0.097 g/100 mL (0 °C)
0.081 g/100 mL (25 °C)
|Solubility||soluble in alcohol, ether, chloroform, benzene, naphtha, CS2, formic acid|
|Vapor pressure||11.94 kPa at 20 °C|
|2.76x10−2 atm-cu m/mol|
Refractive index (nD)
|132.6 J/mol K|
|214.42 J/mol K|
Std enthalpy of
Gibbs free energy (ΔfG˚)
|Safety data sheet||See: data page
|EU classification||T N|
|R-phrases||R23/24/25, R40, R48/23, R59, R52/53|
|S-phrases||(S1/2), S23, S36/37, S45, S59, S61|
|982 °C (1,800 °F; 1,255 K)|
|Lethal dose or concentration (LD, LC):|
LD50 (Median dose)
LC50 (Median concentration)
|5400 ppm (mammal)
8000 ppm (rat, 4 hr)
9526 ppm (mouse, 8 hr)2
LCLo (Lowest published)
|1000 ppm (human)
20,000 ppm (guinea pig, 2 hr)
38,110 ppm (cat, 2 hr)
50,000 ppm (human, 5 min)
14,620 ppm (dog, 8 hr)2
|US health exposure limits (NIOSH):|
|TWA 10 ppm C 25 ppm 200 ppm (5-minute maximum peak in any 4 hours)1|
|Ca ST 2 ppm (12.6 mg/m3) [60-minute]1|
IDLH (Immediate danger
|Supplementary data page|
|Refractive index (n),
Dielectric constant (εr), etc.
|UV, IR, NMR, MS|
Except where otherwise noted, data are given for materials in their standard state (at 25 °C [77 °F], 100 kPa).
|what is: / ?)(|
Carbon tetrachloride, also known by many other names (the most notable being tetrachloromethane (also recognized by the IUPAC), carbon tet in the cleaning industry, Halon-104 in firefighting and Refrigerant-10 in HVACR), is the organic compound with the chemical formula CCl4. It was formerly widely used in fire extinguishers, as a precursor to refrigerants, and as a cleaning agent. It is a colourless liquid with a "sweet" smell that can be detected at low levels.
- CH4 + 4 Cl2 → CCl4 + 4 HCl
- C2Cl6 + Cl2 → 2 CCl4
The production of carbon tetrachloride has steeply declined since the 1980s due to environmental concerns and the decreased demand for CFCs, which were derived from carbon tetrachloride. In 1992, production in the U.S.-Europe-Japan was estimated at 720,000 tonnes.4
In the carbon tetrachloride molecule, four chlorine atoms are positioned symmetrically as corners in a tetrahedral configuration joined to a central carbon atom by single covalent bonds. Because of this symmetrical geometry, CCl4 is non-polar. Methane gas has the same structure, making carbon tetrachloride a halomethane. As a solvent, it is well suited to dissolving other non-polar compounds, fats, and oils. It can also dissolve iodine. It is somewhat volatile, giving off vapors with a smell characteristic of other chlorinated solvents, somewhat similar to the tetrachloroethylene smell reminiscent of dry cleaners' shops.
At −47.3 °C it has monoclinic crystal structure with space group C2/c and lattice constants a = 20.3, b = 11.6, c = 19.9 (.10−1 nm), β = 111°.6 With a specific gravity greater than 1, carbon tetrachloride will be present as a dense nonaqueous phase liquid if sufficient quantities are spilled in the environment.
Historically, carbon tetrachloride was used for a variety of purposes. However, once it became apparent that carbon tetrachloride exposure had severe adverse health effects, such as causing fulminant hepatic necrosis, safer alternatives such as tetrachloroethylene were found for these applications, and its use in these roles declined from about 1940 onward. Carbon tetrachloride persisted as a pesticide to kill insects in stored grain, but in 1970 it was banned in consumer products in the United States.
Prior to the Montreal Protocol, large quantities of carbon tetrachloride were used to produce the chlorofluorocarbon refrigerants R-11 (trichlorofluoromethane) and R-12 (dichlorodifluoromethane). However, these refrigerants play a role in ozone depletion and have been phased out. Carbon tetrachloride is still used to manufacture less destructive refrigerants. Carbon tetrachloride has also been used in the detection of neutrinos.
Carbon tetrachloride has practically no flammability at lower temperatures. Under high temperatures in air, it forms poisonous phosgene. In organic chemistry, carbon tetrachloride serves as a source of chlorine in the Appel reaction.
Because it has no C-H bonds, carbon tetrachloride does not easily undergo free-radical reactions. Hence, it is a useful solvent for halogenations either by the elemental halogen or by a halogenation reagent such as N-bromosuccinimide (these conditions are known as Wohl-Ziegler Bromination).
It is used as a solvent in synthetic chemistry research, but, because of its adverse health effects, it is no longer commonly used, and in general chemists try to replace it with other solvents.7 It is sometimes useful as a solvent for infrared spectroscopy, because there are no significant absorption bands > 1600 cm−1. Because carbon tetrachloride does not have any hydrogen atoms, it was historically used in proton NMR spectroscopy. However, carbon tetrachloride is toxic, and its dissolving power is low.9 Its use has been largely superseded by deuterated solvents. Use of carbon tetrachloride in determination of oil has been replaced by various other solvents, such as tetrachloroethylene.7
In 1910, The Pyrene Manufacturing Company of Delaware filed a patent to use carbon tetrachloride to extinguish fires.10 The liquid vaporized and extinguished the flames by inhibiting the chemical chain reaction of the combustion process (it was an early 20th-century presupposition that the fire suppression ability of carbon tetrachloride relied on oxygen removal.) In 1911, they patented a small, portable extinguisher that used the chemical.11 This consisted of a brass bottle with an integrated handpump that was used to expel a jet of liquid toward the fire. As the container was unpressurized, it could be easily refilled after use.12 Carbon tetrachloride was suitable for liquid and electrical fires and the extinguishers were often carried on aircraft or motor vehicles.
A formerly common form of fire extinguishers consisted of a glass globe, known as a "fire grenades", and were filled with either carbon tetrachloride or salt-water. It was intended that the bulb simply be thrown at the base of the flames.
One specialty use of carbon tetrachloride was in stamp collecting, to reveal watermarks on postage stamps without damaging them. A small amount of the liquid was placed on the back of a stamp, sitting in a black glass or obsidian tray. The letters or design of the watermark could then be clearly seen.
Exposure to high concentrations of carbon tetrachloride (including vapor) can affect the central nervous system, degenerate the liver8 and kidneys14 and may result (after prolonged exposure) in coma and even death.15 Chronic exposure to carbon tetrachloride can cause liver1617 and kidney damage and could result in cancer.18 See safety data sheets.19
In 2008, a study of common cleaning products found the presence of carbon tetrachloride in "very high concentrations" (up to 101 mg/m3) as a result of manufacturers' mixing of surfactants or soap with sodium hypochlorite (bleach).20
Like many other volatile substances, carbon tetrachloride is prone to misuse by inhalation, due to its possible depressant and/or dissociative effect upon the central nervous system. Use of carbon tetrachloride in this manner presents serious health risks, and may result in toxic effects described above.
Carbon tetrachloride is also both ozone-depleting21 and a greenhouse gas.22 However, since 199223 its atmospheric concentrations have been in decline for the reasons described above (see also the atmospheric time-series figure). CCl4 has an atmospheric lifetime of 85 years.24
- "NIOSH Pocket Guide to Chemical Hazards #0107". National Institute for Occupational Safety and Health (NIOSH).
- "Carbon tetrachloride". Immediately Dangerous to Life and Health. National Institute for Occupational Safety and Health (NIOSH).
- V. Regnault (1839) "Sur les chlorures de carbone CCl et CCl2" (On the chlorides of carbon CCl and CCl2 ), Annales de Chimie et de Physique, vol. 70, pages 104-107. Reprinted in German as: V. Regnault (1839). "Ueber die Chlorverbindungen des Kohlenstoffs, C2Cl2 und CCl2". Annalen der Pharmacie 30 (3): 350–352. doi:10.1002/jlac.18390300310.
- Manfred Rossberg, Wilhelm Lendle, Gerhard Pfleiderer, Adolf Tögel, Eberhard-Ludwig Dreher, Ernst Langer, Heinz Jaerts, Peter Kleinschmidt, Heinz Strack, Richard Cook, Uwe Beck, Karl-August Lipper, Theodore R. Torkelson, Eckhard Löser, Klaus K. Beutel, "Chlorinated Hydrocarbons" in Ullmann's Encyclopedia of Industrial Chemistry, 2006 Wiley-VCH, Weinheim.doi:10.1002/14356007.a06_233.pub2
- Carbon tetrachloride
- F. Brezina, J. Mollin, R. Pastorek, Z. Sindelar. Chemicke tabulky anorganickych sloucenin (Chemical tables of inorganic compounds). SNTL, 1986.
- Use of Ozone Depleting Substances in Laboratories. TemaNord 516/2003.dead link
- Seifert WF, Bosma A, Brouwer A; Bosma; Brouwer; Hendriks; Roholl; Van Leeuwen; Van Thiel-De Ruiter; Seifert-Bock; Knook; et al. (January 1994). "Vitamin A deficiency potentiates carbon tetrachloride-induced liver fibrosis in rats". Hepatology 19 (1): 193–201. doi:10.1002/hep.1840190129. PMID 8276355.
- W. Reusch. "Introduction to Nuclear Magnetic Resonance Spectroscopy". Virtual Textbook of Organic Chemistry. Michigan State University.dead link
- U.S. Patent 1,010,870, filed April 5, 1910.
- U.S. Patent 1,105,263, filed Jan 7, 1911.
- "Pyrene Fire Extinguishers". Vintage Fire Extinguishers. Retrieved 23 December 2009.
- Doherty RE (2000). "A History of the Production and Use of Carbon Tetrachloride, Tetrachloroethylene, Trichloroethylene and 1,1,1-Trichloroethane in the United States: Part 1—Historical Background; Carbon Tetrachloride and Tetrachloroethylene". Environmental Forensics 1 (1): 69–81. doi:10.1006/enfo.2000.0010.
- Liu KX, Kato Y, Yamazaki M, Higuchi O, Nakamura T, Sugiyama Y; Kato; Yamazaki; Higuchi; Nakamura; Sugiyama (April 1993). "Decrease in the hepatic clearance of hepatocyte growth factor in carbon tetrachloride-intoxicated rats". Hepatology 17 (4): 651–60. doi:10.1002/hep.1840170420. PMID 8477970.
- Recknagel R.O., Glende E.A., Dolak J.A., Waller R.L.; Glende; Dolak; Waller (1989). "Mechanism of Carbon-tetrachloride Toxicity". Pharmacology Therapeutics 43 (43): 139–154. doi:10.1016/0163-7258(89)90050-8.
- Recknagel RO (June 1967). "Carbon tetrachloride hepatotoxicity". Pharmacol. Rev. 19 (2): 145–208. PMID 4859860.
- Masuda Y (October 2006). "[Learning toxicology from carbon tetrachloride-induced hepatotoxicity]". Yakugaku Zasshi (in Japanese) 126 (10): 885–99. doi:10.1248/yakushi.126.885. PMID 17016019.
- Rood AS, McGavran PD, Aanenson JW, Till JE; McGavran; Aanenson; Till (August 2001). "Stochastic estimates of exposure and cancer risk from carbon tetrachloride released to the air from the rocky flats plant". Risk Anal. 21 (4): 675–95. doi:10.1111/0272-4332.214143. PMID 11726020.
- Material Safety Data Sheet, Carbon tetrachloride at Fisher Scientific
- Odabasi M (2008). "Halogenated Volatile Organic Compounds from the Use of Chlorine-Bleach-Containing Household Products". Environmental Science & Technology 42 (5): 1445–51. Bibcode:2008EnST...42.1445O. doi:10.1021/es702355u.
- Fraser P. (1997). "Chemistry of stratospheric ozone and ozone depletion". Australian Meteorological Magazine 46 (3): 185–193.
- Evans WFJ, Puckrin E; Puckrin (1996). "A measurement of the greenhouse radiation associated with carbon tetrachloride (CCl4)". Geophysical Research Letters 23 (14): 1769–72. Bibcode:1996GeoRL..23.1769E. doi:10.1029/96GL01258.
- Walker, S. J., R. F. Weiss & P. K. Salameh; Weiss; Salameh (2000). "Reconstructed histories of the annual mean atmospheric mole fractions for the halocarbons CFC-11, CFC-12, CFC-113 and carbon tetrachloride". Journal of Geophysical Research 105: 14285–96. Bibcode:2000JGR...10514285W. doi:10.1029/1999JC900273.
- The Atlas of Climate Change (2006) by Kirstin Dow and Thomas E. Downing ISBN 978-0-520-25558-6
- International Chemical Safety Card 0024
- "NIOSH Pocket Guide to Chemical Hazards #0107". National Institute for Occupational Safety and Health (NIOSH).
- "Carbon Tetrachloride (Group 2B)". International Agency for Research on Cancer (IARC) – Summaries & Evaluations 71: 401. 1999.
- IARC Monograph: "Carbon Tetrachloride"dead link
- Toxicological profile for carbon tetrachloride
- Environmental health criteria for carbon tetrachloride
- Carbon tetrachloride MSDS at Hazardous Chemical Database
- MSDS at Oxford University
- Egli C, Tschan T, Scholtz R, Cook AM, Leisinger T; Tschan; Scholtz; Cook; Leisinger (November 1988). "Transformation of tetrachloromethane to dichloromethane and carbon dioxide by Acetobacterium woodii". Appl. Environ. Microbiol. 54 (11): 2819–24. PMC 204379. PMID 3145712.|
- Picardal FW, Arnold RG, Couch H, Little AM, Smith ME; Arnold; Couch; Little; Smith (November 1993). "Involvement of cytochromes in the anaerobic biotransformation of tetrachloromethane by Shewanella putrefaciens 200". Appl. Environ. Microbiol. 59 (11): 3763–70. PMC 182529. PMID 8285682.
- Substance profile at ntp.niehs.nih.govdead link
- ChemSub Online: Carbon tetrachloride.